https://doi.org/10.4081/jae.2022.1334
Comparative study of coating agents for prevention of fine-dust-induced light transmittance reduction in greenhouse covering materials
Published: 29 June 2022
Abstract Views: 935
PDF: 411
HTML: 37
HTML: 37
Publisher's note
All claims expressed in this article are solely those of the authors and do not necessarily represent those of their affiliated organizations, or those of the publisher, the editors and the reviewers. Any product that may be evaluated in this article or claim that may be made by its manufacturer is not guaranteed or endorsed by the publisher.
All claims expressed in this article are solely those of the authors and do not necessarily represent those of their affiliated organizations, or those of the publisher, the editors and the reviewers. Any product that may be evaluated in this article or claim that may be made by its manufacturer is not guaranteed or endorsed by the publisher.
Authors
Recently, rapidly growing industry and abnormal climate change have generated high concentrations of fine dust. This fine dust settles on greenhouses and hinders photosynthesis of the plants within. In this study, the greenhouse environment was reproduced using fine dust devices, and the fine dust adhesion and washing efficiency were compared. The optimal coating agent was selected by performing a coating experiment to assess the changes in the light transmittance and contact angles of eight greenhouse coatings incorporating different coating agents. The most pronounced adhesion rate was observed in an ion humidification test for (NH4)2SO4. The coating agent with Teflon, which exhibited the largest contact angle in this study, had the highest washing efficiency, followed by the coating agent with the highest polydimethylsiloxane ratio using isopropyl alcohol (IPA) as a solvent, and the coating agent with the highest polydimethylsiloxane using water as a solvent. However, the ingredients added to the agents with Teflon or IPA were judged inappropriate for greenhouse use due to environmental reasons. Therefore, the coating agent with the highest polydimethylsiloxane using water as a solvent, which is the most suitable coating agent and satisfies both the washing efficiency and contact angle requirements, is expected to be used as a greenhouse coating agent to prevent light transmittance reduction in greenhouses due to fine dust accumulation.
Abdel-Ghany A.M., Al-Helal I.M., Picuno P., Shady M.R. 2016. Modified plastic net-houses as alternative agricultural structures for saving energy and water in hot and sunny regions. Renew. Energ. 93:332-9.
DOI: https://doi.org/10.1016/j.renene.2016.02.084
Alados I., Foyo-Moreno I.Y., Alados-Arboledas L. 1996. Photosynthetically active radiation: measurements and modelling. Agr. Forest Meteorol. 78:121-31.
DOI: https://doi.org/10.1016/0168-1923(95)02245-7
Byun Y.S., Chung S.W., Yoo S.O., Yu M.H., Jun D.H. 2009. Adsorption and desorption performance of toluene and IPA for ACF and activated carbon. Appl. Chem. 13:65-8.
Challa H., Schapendonk A.H.C.M. 1984. Quantification of effects of light reduction in greenhouses on yield. Acta Hortic. 148:501-10.
DOI: https://doi.org/10.17660/ActaHortic.1984.148.63
Chang D.S., Lee H.J. 2011. A study on the function and application of the glasses for rolling stock. Proc. KSR Conf. 1097-108.
Choi C.S., Han K.S., Hwang K.T., Kim J.H. 2019. Hydrophobic property of surface glaze of ceramic tiles by copper powder addition. J. Korean Growth Crystal Technol. 29:215-21.
Choi T.O., Lee G.Y. 2017. Development of cookware product design converging with eco-friendly food culture contents. J. Korea Converge. Soc. 8:167-73.
Chun H., Kim K.J., Kim J.Y., Kim H.H., Lee S.Y. 2000. Effect of plasma film covered greenhouse on anti-water drop and green pepper (Capsicum annuum L.) growth. Korean Soc. Bio-Environ. Control. 124-7.
Cockshull K.E., Graves C.J., Cave C.R.J. 1992. The influence of shading on yield of glasshouse tomatoes. J. Hortic. Sci. 67:11-24.
DOI: https://doi.org/10.1080/00221589.1992.11516215
Djakhdane K., Dehbi A., Mourad A.I., Zaoui A., Picuno P. 2016. The effect of sand wind, temperature and exposure time on tri-layer polyethylene film used as greenhouse roof. Plast. Rubber Compos. 45:346-51.
DOI: https://doi.org/10.1080/14658011.2016.1198860
Ge J.C., Wang Z.J., Yoon S.K., Choi N.J. 2018. Fabrication of electrospun PAN/FA nanocomposites and their adsorption effects for reducing volatile organic compounds. Korea Acad.-Ind. Coop. Soc. 19:702-8.
Health Effects Institute. 2017. State of global air 2016.
Jeon B.I. 2017. Characteristics of metallic and ionic concentration in fine particle during haze day in Busan. J. Environ. Sci. Intl. 26:767-78.
DOI: https://doi.org/10.5322/JESI.2017.26.6.767
Jeon H., Kim H.H., Lee S.Y., Kim K.J. 2002. Effect of yellow dust on transmittance of covering materials in greenhouse. Korean Soc. Bio-Environ. Control. 11:57-9.
Jeong J.C., Lee S.H. 2018. Spatial distribution of particulate matters in comparison with land-use and traffic volume in Seoul, Republic of Korea. J. Cadastre. Land InformatiX. 48:123-38.
Jokisch S., Neuenfeldt M., Scheibel T. 2017. Silk‐based fine dust filters for air filtration. Adv. Sustain. Syst. 1:1700079.
DOI: https://doi.org/10.1002/adsu.201700079
Jung B.C. 2002. Biosurfactant of microorganisms. BioWave. 4:9.
Kim H.H., Chang Y.S., Kim D.E., Lee K.M., Kim J.G., Lee D.H., Kim S.K. 2003. Development of cleaning equipment on single span greenhouse covering with plastic. Korean Soc. Bio-Environ. Control. 209-12.
Korea Optical Industry Association. 2006. IPA. The Optical J. 105:66-7.
Kraugerud M., Zimmer K.E., Ropstad E., Verhaegen S. 2011. Perfluorinated compounds differentially affect steroidogenesis and viability in the human adrenocortical carcinoma (H295R) in vitro cell assay. Toxicol. Lett. 205:62-8.
DOI: https://doi.org/10.1016/j.toxlet.2011.05.230
Li X.M., Reinhoudt D., Crego-Calama M. 2007. What do we need for a superhydrophobic surface? A review on the recent progress in the preparation of superhydrophobic surfaces. Chem. Soc. Rev. 36:1350-68.
DOI: https://doi.org/10.1039/b602486f
Lim H.S. 2012. Development of nanostructured superhydrophobic surfaces. Korea Soc. Indust. Chem. 15:11-22.
Logsdon J.E., Loke R.A. 2000. Isopropyl alcohol. Kirk‐Othmer Encyclopedia. Chem. Technol. Wiley, New York, NY, USA.
DOI: https://doi.org/10.1002/0471238961.0919151612150719.a01
Ministry of Environment. 2017. Yearbook of atmospheric environment 2016.
Ministry of Environment. 2020. Yearbook of air quality 2019.
Ministry of Environment. 2019. Manual for implementing emergency reduction measures for high concentrations of fine dust in the metropolitan area.
Ministry of Agriculture, Food and Rural Affairs (MAFRA). 2014. Horticultural Specialized Facilities Internal Solution Specification Design and Specification.
Ministry of Agriculture, Food and Rural Affairs (MAFRA). 2019. Greenhouse and protected vegetable production statistics 2018. Ministry of Agriculture, Food and Rural Affairs, Sejong.
Mnif I., Ghribi D. 2016. Glycolipid biosurfactants: main properties and potential applications in agriculture and food industry. J. Sci. Food Agric. 96:4310-20.
DOI: https://doi.org/10.1002/jsfa.7759
Moon J.P., Park S.H., Kim J.G., Lee J.H., Kang Y.K., Lim M.Y., Kim H.M. 2020. Yield increase and energy saving effect on plastic greenhouse covered with polyolefin film. J. Bio-Environ. Control. 29:428-39.
DOI: https://doi.org/10.12791/KSBEC.2020.29.4.428
Nam S.W., Kim Y.S. 2009. Actual state of structures and environmental control facilities for tomato greenhouses in Chungnam region. Korean J. Agr. Sci. 36:73-85.
Park K.S., Lee G.M., Kim J.M. 1997. Development of a cleaning machine for plastic film roof. Curr. Res. Agric. Life. Sci. 15:123-31.
Park J.S., Kim C.H., Lee J.J., Kim J.H., Hwang E.H., Kim S.D. 2010. A study on the chemical composition characteristics of fine dust in Seoul. J. Korean Soc. Urban. Environ. 10:293-303.
Seo H.H., Kim J.K., Kang S.J. 2005. Effect of artificial Asian dust spraying on fruiting and qualities in fruit trees. Korean Soc. Agr. Forest Meteorol. 222-5.
So P.B., Tang P.H., Liao B.S., Sathishkumar N., Chen H.T., Lin C.H. 2021. Sustainable scale-up synthesis of MIL-68 (Al) using IPA as solvent for acetic acid capture. Microporous Mesoporous Mater. 316:110943.
DOI: https://doi.org/10.1016/j.micromeso.2021.110943
Taylor L.J., Lee R.S., Long M., Rawlings A.V., Tubek J., Whitehead L., Moss G.P. 2002. Effect of occlusion on the percutaneous penetration of linoleic acid and glycerol. Int. J. Pharm. 249:157-64.
DOI: https://doi.org/10.1016/S0378-5173(02)00489-1
Umar A., Zafar A., Wali H., Siddique M.P., Qazi M.A., Naeem A.H., Ahmed S. 2021. Low-cost production and application of lipopeptide for bioremediation and plant growth by Bacillus subtilis SNW3. AMB Express. 11:1-21.
DOI: https://doi.org/10.1186/s13568-021-01327-0
WHO Regional Office for Europe. 2006. Air quality guidelines: global update, 2005.
Wenzel R.N. 1936. Resistance of solid surfaces to wetting by water. Ind. Eng. Chem. 28:988-94.
DOI: https://doi.org/10.1021/ie50320a024
Yu B.S. 1996. Automotive windows glass and their development trend. J. Korean Soc. Automot. Engineers. 18:82-95.
How to Cite
Seo, Y.- jin (2022) “Comparative study of coating agents for prevention of fine-dust-induced light transmittance reduction in greenhouse covering materials”, Journal of Agricultural Engineering, 53(2). doi: 10.4081/jae.2022.1334.
Copyright (c) 2022 the Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
PAGEPress has chosen to apply the Creative Commons Attribution NonCommercial 4.0 International License (CC BY-NC 4.0) to all manuscripts to be published.
Similar Articles
- Pietro Catania, Filippa Bono, Claudio De Pasquale, Mariangela Vallone, Closed tank pneumatic press application to improve Sauvignon Blanc wine quality and nutraceutical properties , Journal of Agricultural Engineering: Vol. 50 No. 4 (2019)
- Giovanni Russo, Giuseppe Verdiani, The health risk of the agricultural production in potentially contaminated sites: an environmental-health risk analysis , Journal of Agricultural Engineering: Vol. 43 No. 3 (2012)
- Bing Li, Jiyun Li, Key technology of crop precision sowing based on the vision principle , Journal of Agricultural Engineering: Vol. 54 No. 1 (2023)
- Giuseppe Rossi, Leonardo Conti, Lorenzo Fiorineschi , Massimiliano Marvasi, Massimo Monti, Federico Rotini, Marco Togni, Matteo Barbari, A new eco-friendly packaging material made of straw and bioplastic , Journal of Agricultural Engineering: Vol. 51 No. 4 (2020)
- Siti Hanggita Rachmawati, Zakaria Hossain, Jim Shiau, Ground improvement using waste shell for farm roads and embankments , Journal of Agricultural Engineering: Vol. 49 No. 1 (2018)
- Maria Lodovica Gullino, Massimo Pugliese, Alessandro Paravicini, Enzo Casulli, Andrea Rettori, Mattia Sanna, Angelo Garibaldi, NEW PHYTOTRON FOR STUDYING THE EFFECT OF CLIMATE CHANGE ON PLANT PATHOGENS , Journal of Agricultural Engineering: Vol. 42 No. 1 (2011)
- Christopher O. Akinbile, Remigius C. Eze, Habeeb Yusuf, Babatunde S. Ewulo, Adeniyi Olayanju, Effect of some selected soil properties, moisture content, yield and consumptive water use on two Cassava (TMS 0581 and TME 419) varieties , Journal of Agricultural Engineering: Vol. 50 No. 4 (2019)
- F. Delai, J. Moretto, L. Mao, L. Picco, M.A. Lenzi, Evaluation of short-term geomorphic changes in differently impacted gravel-bed rivers using improved dems of difference , Journal of Agricultural Engineering: Vol. 44 No. s2 (2013): Proceedings of the 10th Conference of the Italian Society of Agricultural Engineering
- C.A. Campiotti, E. Schettini, G. Alonzo, C. Viola, C. Bibbiani, G. Scarascia Mugnozza, I. Blanco, G. Vox, Building green covering for a sustainable use of energy , Journal of Agricultural Engineering: Vol. 44 No. s2 (2013): Proceedings of the 10th Conference of the Italian Society of Agricultural Engineering
- Sonia Castellucci, Silvia Cocchi, Elena Allegrini, Luigi Vecchione, Anaerobic digestion and co-digestion of slaughterhouse wastes , Journal of Agricultural Engineering: Vol. 44 No. s2 (2013): Proceedings of the 10th Conference of the Italian Society of Agricultural Engineering
<< < 27 28 29 30 31 32 33 34 35 36 > >>
You may also start an advanced similarity search for this article.
