https://doi.org/10.4081/jae.2022.1334
Comparative study of coating agents for prevention of fine-dust-induced light transmittance reduction in greenhouse covering materials
Published: 29 June 2022
Abstract Views: 935
PDF: 411
HTML: 37
HTML: 37
Publisher's note
All claims expressed in this article are solely those of the authors and do not necessarily represent those of their affiliated organizations, or those of the publisher, the editors and the reviewers. Any product that may be evaluated in this article or claim that may be made by its manufacturer is not guaranteed or endorsed by the publisher.
All claims expressed in this article are solely those of the authors and do not necessarily represent those of their affiliated organizations, or those of the publisher, the editors and the reviewers. Any product that may be evaluated in this article or claim that may be made by its manufacturer is not guaranteed or endorsed by the publisher.
Authors
Recently, rapidly growing industry and abnormal climate change have generated high concentrations of fine dust. This fine dust settles on greenhouses and hinders photosynthesis of the plants within. In this study, the greenhouse environment was reproduced using fine dust devices, and the fine dust adhesion and washing efficiency were compared. The optimal coating agent was selected by performing a coating experiment to assess the changes in the light transmittance and contact angles of eight greenhouse coatings incorporating different coating agents. The most pronounced adhesion rate was observed in an ion humidification test for (NH4)2SO4. The coating agent with Teflon, which exhibited the largest contact angle in this study, had the highest washing efficiency, followed by the coating agent with the highest polydimethylsiloxane ratio using isopropyl alcohol (IPA) as a solvent, and the coating agent with the highest polydimethylsiloxane using water as a solvent. However, the ingredients added to the agents with Teflon or IPA were judged inappropriate for greenhouse use due to environmental reasons. Therefore, the coating agent with the highest polydimethylsiloxane using water as a solvent, which is the most suitable coating agent and satisfies both the washing efficiency and contact angle requirements, is expected to be used as a greenhouse coating agent to prevent light transmittance reduction in greenhouses due to fine dust accumulation.
Abdel-Ghany A.M., Al-Helal I.M., Picuno P., Shady M.R. 2016. Modified plastic net-houses as alternative agricultural structures for saving energy and water in hot and sunny regions. Renew. Energ. 93:332-9.
DOI: https://doi.org/10.1016/j.renene.2016.02.084
Alados I., Foyo-Moreno I.Y., Alados-Arboledas L. 1996. Photosynthetically active radiation: measurements and modelling. Agr. Forest Meteorol. 78:121-31.
DOI: https://doi.org/10.1016/0168-1923(95)02245-7
Byun Y.S., Chung S.W., Yoo S.O., Yu M.H., Jun D.H. 2009. Adsorption and desorption performance of toluene and IPA for ACF and activated carbon. Appl. Chem. 13:65-8.
Challa H., Schapendonk A.H.C.M. 1984. Quantification of effects of light reduction in greenhouses on yield. Acta Hortic. 148:501-10.
DOI: https://doi.org/10.17660/ActaHortic.1984.148.63
Chang D.S., Lee H.J. 2011. A study on the function and application of the glasses for rolling stock. Proc. KSR Conf. 1097-108.
Choi C.S., Han K.S., Hwang K.T., Kim J.H. 2019. Hydrophobic property of surface glaze of ceramic tiles by copper powder addition. J. Korean Growth Crystal Technol. 29:215-21.
Choi T.O., Lee G.Y. 2017. Development of cookware product design converging with eco-friendly food culture contents. J. Korea Converge. Soc. 8:167-73.
Chun H., Kim K.J., Kim J.Y., Kim H.H., Lee S.Y. 2000. Effect of plasma film covered greenhouse on anti-water drop and green pepper (Capsicum annuum L.) growth. Korean Soc. Bio-Environ. Control. 124-7.
Cockshull K.E., Graves C.J., Cave C.R.J. 1992. The influence of shading on yield of glasshouse tomatoes. J. Hortic. Sci. 67:11-24.
DOI: https://doi.org/10.1080/00221589.1992.11516215
Djakhdane K., Dehbi A., Mourad A.I., Zaoui A., Picuno P. 2016. The effect of sand wind, temperature and exposure time on tri-layer polyethylene film used as greenhouse roof. Plast. Rubber Compos. 45:346-51.
DOI: https://doi.org/10.1080/14658011.2016.1198860
Ge J.C., Wang Z.J., Yoon S.K., Choi N.J. 2018. Fabrication of electrospun PAN/FA nanocomposites and their adsorption effects for reducing volatile organic compounds. Korea Acad.-Ind. Coop. Soc. 19:702-8.
Health Effects Institute. 2017. State of global air 2016.
Jeon B.I. 2017. Characteristics of metallic and ionic concentration in fine particle during haze day in Busan. J. Environ. Sci. Intl. 26:767-78.
DOI: https://doi.org/10.5322/JESI.2017.26.6.767
Jeon H., Kim H.H., Lee S.Y., Kim K.J. 2002. Effect of yellow dust on transmittance of covering materials in greenhouse. Korean Soc. Bio-Environ. Control. 11:57-9.
Jeong J.C., Lee S.H. 2018. Spatial distribution of particulate matters in comparison with land-use and traffic volume in Seoul, Republic of Korea. J. Cadastre. Land InformatiX. 48:123-38.
Jokisch S., Neuenfeldt M., Scheibel T. 2017. Silk‐based fine dust filters for air filtration. Adv. Sustain. Syst. 1:1700079.
DOI: https://doi.org/10.1002/adsu.201700079
Jung B.C. 2002. Biosurfactant of microorganisms. BioWave. 4:9.
Kim H.H., Chang Y.S., Kim D.E., Lee K.M., Kim J.G., Lee D.H., Kim S.K. 2003. Development of cleaning equipment on single span greenhouse covering with plastic. Korean Soc. Bio-Environ. Control. 209-12.
Korea Optical Industry Association. 2006. IPA. The Optical J. 105:66-7.
Kraugerud M., Zimmer K.E., Ropstad E., Verhaegen S. 2011. Perfluorinated compounds differentially affect steroidogenesis and viability in the human adrenocortical carcinoma (H295R) in vitro cell assay. Toxicol. Lett. 205:62-8.
DOI: https://doi.org/10.1016/j.toxlet.2011.05.230
Li X.M., Reinhoudt D., Crego-Calama M. 2007. What do we need for a superhydrophobic surface? A review on the recent progress in the preparation of superhydrophobic surfaces. Chem. Soc. Rev. 36:1350-68.
DOI: https://doi.org/10.1039/b602486f
Lim H.S. 2012. Development of nanostructured superhydrophobic surfaces. Korea Soc. Indust. Chem. 15:11-22.
Logsdon J.E., Loke R.A. 2000. Isopropyl alcohol. Kirk‐Othmer Encyclopedia. Chem. Technol. Wiley, New York, NY, USA.
DOI: https://doi.org/10.1002/0471238961.0919151612150719.a01
Ministry of Environment. 2017. Yearbook of atmospheric environment 2016.
Ministry of Environment. 2020. Yearbook of air quality 2019.
Ministry of Environment. 2019. Manual for implementing emergency reduction measures for high concentrations of fine dust in the metropolitan area.
Ministry of Agriculture, Food and Rural Affairs (MAFRA). 2014. Horticultural Specialized Facilities Internal Solution Specification Design and Specification.
Ministry of Agriculture, Food and Rural Affairs (MAFRA). 2019. Greenhouse and protected vegetable production statistics 2018. Ministry of Agriculture, Food and Rural Affairs, Sejong.
Mnif I., Ghribi D. 2016. Glycolipid biosurfactants: main properties and potential applications in agriculture and food industry. J. Sci. Food Agric. 96:4310-20.
DOI: https://doi.org/10.1002/jsfa.7759
Moon J.P., Park S.H., Kim J.G., Lee J.H., Kang Y.K., Lim M.Y., Kim H.M. 2020. Yield increase and energy saving effect on plastic greenhouse covered with polyolefin film. J. Bio-Environ. Control. 29:428-39.
DOI: https://doi.org/10.12791/KSBEC.2020.29.4.428
Nam S.W., Kim Y.S. 2009. Actual state of structures and environmental control facilities for tomato greenhouses in Chungnam region. Korean J. Agr. Sci. 36:73-85.
Park K.S., Lee G.M., Kim J.M. 1997. Development of a cleaning machine for plastic film roof. Curr. Res. Agric. Life. Sci. 15:123-31.
Park J.S., Kim C.H., Lee J.J., Kim J.H., Hwang E.H., Kim S.D. 2010. A study on the chemical composition characteristics of fine dust in Seoul. J. Korean Soc. Urban. Environ. 10:293-303.
Seo H.H., Kim J.K., Kang S.J. 2005. Effect of artificial Asian dust spraying on fruiting and qualities in fruit trees. Korean Soc. Agr. Forest Meteorol. 222-5.
So P.B., Tang P.H., Liao B.S., Sathishkumar N., Chen H.T., Lin C.H. 2021. Sustainable scale-up synthesis of MIL-68 (Al) using IPA as solvent for acetic acid capture. Microporous Mesoporous Mater. 316:110943.
DOI: https://doi.org/10.1016/j.micromeso.2021.110943
Taylor L.J., Lee R.S., Long M., Rawlings A.V., Tubek J., Whitehead L., Moss G.P. 2002. Effect of occlusion on the percutaneous penetration of linoleic acid and glycerol. Int. J. Pharm. 249:157-64.
DOI: https://doi.org/10.1016/S0378-5173(02)00489-1
Umar A., Zafar A., Wali H., Siddique M.P., Qazi M.A., Naeem A.H., Ahmed S. 2021. Low-cost production and application of lipopeptide for bioremediation and plant growth by Bacillus subtilis SNW3. AMB Express. 11:1-21.
DOI: https://doi.org/10.1186/s13568-021-01327-0
WHO Regional Office for Europe. 2006. Air quality guidelines: global update, 2005.
Wenzel R.N. 1936. Resistance of solid surfaces to wetting by water. Ind. Eng. Chem. 28:988-94.
DOI: https://doi.org/10.1021/ie50320a024
Yu B.S. 1996. Automotive windows glass and their development trend. J. Korean Soc. Automot. Engineers. 18:82-95.
How to Cite
Seo, Y.- jin (2022) “Comparative study of coating agents for prevention of fine-dust-induced light transmittance reduction in greenhouse covering materials”, Journal of Agricultural Engineering, 53(2). doi: 10.4081/jae.2022.1334.
Copyright (c) 2022 the Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
PAGEPress has chosen to apply the Creative Commons Attribution NonCommercial 4.0 International License (CC BY-NC 4.0) to all manuscripts to be published.
Similar Articles
- Wei Ji, Tong Zhang, Bo Xu, Guozhi He, Apple recognition and picking sequence planning for harvesting robot in a complex environment , Journal of Agricultural Engineering: Vol. 55 No. 1 (2024)
- Pier Riccardo Porceddu, Laura Rosati, Marco Dionigi, EVALUATION OF TEMPORALVARIATIONS IN MOISTURE AND CALORIFIC VALUE OF VINE AND OLIVE PRUNING , Journal of Agricultural Engineering: Vol. 41 No. 4 (2010)
- Chiara Cevoli, Angelo Fabbri, Simone Virginio Marai, Enrico Ferrari, Adriano Guarnieri, Estimation of thermal conductivity of short pastry biscuit at different baking stages , Journal of Agricultural Engineering: Vol. 45 No. 2 (2014)
- Enrica Santolini, Marco Bovo, Alberto Barbaresi, Daniele Torreggiani, Patrizia Tassinari, Evaluation of microclimate in dairy farms using different model typologies in computational fluid dynamics analyses , Journal of Agricultural Engineering: Vol. 55 No. 3 (2024)
- Michele Carrara, Pietro Catania, Giuseppe Lo Re, Marco Ortolani, Mariangela Vallone, AN INNOVATIVE SYSTEM FOR VINEYARD MANAGEMENT IN SICILY , Journal of Agricultural Engineering: Vol. 41 No. 1 (2010)
- Raffaele Cavalli, Stefano Grigolato, GEOGRAPHICALANALYSIS WITH GIS METHODOLOGY FOR A SUSTAINABLE USE OF LOGGING RESIDUES IN MOUNTAINOUS AREA , Journal of Agricultural Engineering: Vol. 38 No. 3 (2007)
- Luigi Cavazza, Adriano Guarnieri, Antonia Patruno, Giulio Lorenzini, Elio Cirillo, FIRST RESULTS FROM OEDOTENSIOMETRIC TESTS , Journal of Agricultural Engineering: Vol. 39 No. 3 (2008)
- Daniele Torreggiani, Valentina Corzani, Stefano Benni, Patrizia Tassinari, Design of farm winery façades for the optimisation of indoor natural lighting: a case study , Journal of Agricultural Engineering: Vol. 44 No. 1 (2013)
- Angela Calvo, Roberto Deboli, Christian Preti, Antonino De Maria, Daily exposure to hand arm vibration by different electric olive beaters , Journal of Agricultural Engineering: Vol. 45 No. 3 (2014)
- José F. Reyes, Elías Contreras, Christian Correa, Pedro Melin, Image analysis of real-time classification of cherry fruit from colour features , Journal of Agricultural Engineering: Vol. 52 No. 4 (2021)
<< < 35 36 37 38 39 40 41 42 43 44 > >>
You may also start an advanced similarity search for this article.
